Tech Tip: Life, Liberty and the Solution to Trouble Codes

Tech Tip: Life, Liberty and the Solution to Trouble Codes

Kathy enjoys hiking with her dogs. Recently, she traded in her old SUV for a 2005 Jeep Liberty that could comfortably carry the three of them. On a recent drive home from hiking in the mountains, Kathy noticed that the ABS lamp was on. She stopped by my shop a few days later, and after testing, we determined that the rear wheel speed sensor had failed.

By Eric Seifert
Automotive Technical Editor

Kathy enjoys hiking with her dogs. Recently, she traded in her old SUV for a 2005 Jeep Liberty that could comfortably carry the three of them. On a recent drive home from hiking in the mountains, Kathy noticed that the ABS lamp was on. She stopped by my shop a few days later, and after testing, we determined that the rear wheel speed sensor had failed.

Customers may experience a brake/ABS warning light or a Malfunction Indicator Lamp (MIL) illumination. On vehicles equipped with an Anti-Lock Brake System (ABS), a red brake light and/or an amber ABS light may illuminate and remain on. On vehicles NOT equipped with ABS, the MIL may illuminate. The MIL may be due to DTC P0501 – Vehicle Speed Signal Performance/Vehicle Speed Sensor Plausibility.

The condition may be due to a rear differential-mounted wheel speed sensor that is contaminated by the rear axle fluid. If using the Diagnostic Trouble Code Tests available in ALLDATA determines that the sensor requires replacement, perform the Repair Procedure.

Replacement of the rear wheel speed sensor and axle fluid will require the following parts:
• (1) 56041393AA Rear Wheel Speed Sensor;
• (1) 05086373AA Speed Sensor O-Ring;
• 05013477AA Axle RTV;
• 04897151AB Brake Parts Cleaner;
• (3) 05010320AA Mopar Synthetic Gear Lubricant 75W-90OR (3) 04874469 Mopar Synthetic Gear & Axle Lubricant 75W-140 (if towing); and
• (1) 04318060AB Limited Slip Additive (if Trac-Loc equipped).

Applicable Vehicles: 2005 (KJ) Liberty/Cherokee

Repair Procedure:
(Review safety procedures in the ALLDATA system before beginning)

1. Disconnect and isolate the negative battery cable from the battery.

2. Raise the vehicle on a suitable lift.

3. Remove the rear axle differential housing cover.

4. Thoroughly clean the axle, differential and differential cover of old oil, debris and RTV.

5. Remove the rear wheel speed sensor electrical connector. Remove the sensor from the axle.

6. Install the new 0-ring, P/N 05086373AA, to the new rear wheel speed sensor.

7. Lubricate the new rear wheel speed sensor and 0-ring.

8. Install the new rear wheel speed sensor, P/N 56041393AA, to the axle. Tighten the attaching bolt to 9 Nm (80 in. lbs.).

9. Verify that the seal is securely in place between the sensor and wiring connector. Install the sensor electrical connector to the sensor.

10. Apply a bead of Axle RTV sealant, p/n 05013477AA, to the differential housing cover.

CAUTION: If cover is not installed within 3 to 5 minutes of new RTV sealant application, the cover must be cleaned and new RTV sealant applied. Failure to follow instructions will cause a leak.

11. Install the cover and identification tag. Tighten cover bolts in a criss-cross pattern to 41 Nm (30 ft. lbs.).

12. If not already removed, remove the fill plug.

13. If axle is equipped with a Trac-Lok differential, install 4 oz. of Limited Slip Additive to the differential.

14. Fill the axle differential with the correct axle lubricant.

15. Install the fill plug.

16. Verify that the rear wheel speed sensor and differential housing cover is correctly installed.

17. Lower vehicle.

18. Connect the negative battery cable to the battery. Set the clock to the correct time.

Written by ALLDATA Technical Editor, Eric Seifert. Eric is an ASE certified Master Technician and Engine Machinist. He is a graduate of the De Anza College Automotive Technology Program, with 20 years of independent shop and parts store experience.

For additional information, visit www.alldata.com.

You May Also Like

Mobis Starts Construction of EV Battery System Plant in Spain

The new EV battery system plant will supply Volkswagen and is aiming for mass production by 2026.

Mobis announced it has begun building a new electric vehicle battery plant in Navarre, Spain. The company, which has similar facilities in Korea, China, and the Czech Republic, is also developing plants in the U.S. and Indonesia. The Spain plant will focus on serving Volkswagen.

The Mobis plant is expected to start mass production by 2026. The plant will play a crucial role in Mobis' strategy to expand its global footprint and electrification efforts, the company noted in a recent press release. Last year, Mobis secured a major contract to supply battery systems to Volkswagen.

Blink Charging UK, Evri Collaborate to Electrify Courier Fleet

EV chargers installed at Rugby enhance Evri’s sustainability efforts, supporting a greener future in parcel delivery across the UK.

Pricing Alignments

Why ordering off the menu can hurt your shop and customers.

BCA Bearings Unveils 2024 Endless Summer Promotion

The Endless Summer promotion runs from May 1 through June 30, 2024.

PRT Launches 30 New Complete Strut Assemblies

The new items represent more than 10 million vehicles in new coverage, PRT said.

Other Posts

ADAS False Activation Evolution

The logic behind most ADAS warnings or corrections is to examine the plausibility of the situation.

Toe Angles and Ride Height 

Zero toe angle is present when both tires are parallel to the center thrustline.

Sona Comstar Inaugurates Manufacturing Plant in Mexico

The new facility will specialize in producing differential assemblies and reduction gears meticulously designed for BEVs.

Axle Torque Procedures

Guessing the correct torque setting is a bad idea.