Tech Feature: Ignition Coil Diagnostics

Tech Feature: Ignition Coil Diagnostics

Import Specialist Gary Goms says there are a variety of opinions about how to test ignition coils and ignition systems. The most basic method is measuring a coil's primary and secondary resistance. If a coil doesn't meet the manufacturer's specifications, it should be considered defective. But meeting primary and secondary resistance specifications on the bench is no guarantee that the coil will perform correctly under extreme heat and load.

cuits can be a non-current-limiting design, which creates a pointed current ramp waveform. The ICM or PCM primary circuits can also be a current-limiting design that creates a “flat-top” waveform indicating that the primary current is being limited to predetermined values. See Photo 5.

Photo 5: This current ramp represents current flow through a coil-on-plug configuration. Notice that the current is about 4.4 amperes and is non-limited.

Access to the primary circuit can most often be obtained through the “ignition” fuse in the vehicle fuse box or directly at the primary ignition wiring harness leading to the ignition coils. In many cases, all of the system’s ignition coils are powered by a single wire, which simplifies attaching an inductive current probe. In COP ignitions with no other access, a set of jumper wires can be used to attach an inductive current probe. See Photo 6.

Photo 6: Access for an inductive probe can be attained on some COP ignitions by installing jumper wires between the coil connector and coil.

If the coil driver in the PCM is ruined or if an ICM fails, it’s always good procedure to check the current ramp on the ignition coil. Remember that most ignition coils shouldn’t draw more than eight amperes. If in doubt, compare amperage draw with a similar known-good system. If a coil is drawing excessive amperage, the primary circuit might be shorted which, in turn, might ruin the new PCM or ICM. If you’re in doubt about the integrity of any ignition coil, it’s better to replace with new than to risk a costly comeback.

You May Also Like

Grinding/Rubbing Noise While Braking At Or Below 10 MPH

This tech tip involves complaints about brake noise in a Ford Escape Hybrid’s system.

2020-2023 Ford Escape Hybrid 2.5 FHEV

Some 2020-2023 Escape hybrid vehicles equipped with a 2.5L full hybrid electric vehicle (FHEV) powertrain and 4WD may exhibit a grinding or rubbing noise while braking at or below 10 mph from the front of the vehicle. 

This may be due to an inadequate gap between the driveshaft and the heat shield. To correct this condition, follow the service procedure to diagnose and position the heat shield away from the driveshaft.

Transmissions – CVT

Knowing what the common issues are & understanding the options available to isolate & fix problems are the keys to success.

Simplifying AWD Systems

No matter the manufacturer, there is almost always an all-wheel drive (AWD) option.

Manual Transmission Service

Parts that wear out must be replaced.

Transmission Fluid Hydraulics

You need to know how transmission fluid flows inside an automatic transmission.

Other Posts

Advanced Wheel Bearing Diagnostics

Can a bump set a wheel speed sensor code?

How Well Do You Know Your Driveshaft?

There are three types of modern driveshafts with multiple configurations.

Transmission Service

The following is an example of a dishonest vehicle and how to go about catching it in its lie.

Limited-Slip Differentials And Diagnostics

A limited-slip differential helps to control the tangential forces.