Diagnostic Dilemmas: Servicing Quadrajet Carburetors

Diagnostic Dilemmas: Servicing Quadrajet Carburetors

src=”/wp-content/uploads/Articles/05_01_2008/39766Carb4jpg_00000021239.jpg” border=”0″ ” align=”right” alt=”photo 4: float level can easily be measured on the quadrajet.”/>can be measured by inserting a special Kent-Moore float level gauge into the bowl vent located just aft the choke valve. See Photo 4.

Measuring the distance from the top of the bowl vent to the float and then subtracting the dimension from the bowl vent to the cover gasket can also determine the float level. If a repair manual with adjustment specifications is available, refer to the float level specifications listed for the model number stamped vertically on the driver’s side of the carburetor main body or on a tab attached above the primary throttle shaft. Although most Quadrajet float levels are set at 3/8”, the specification can vary from 5/16” to 1/2”.  Last, the metering rod piston can stick in its photo 5: metering rod travel can be easily checked by inserting an applicable tool into the front float bowl vent. bore, causing a lean air/fuel condition. The metering rod travel can be checked by inserting a screwdriver or punch into the bowl vent hole in front of the choke valve to see if the metering piston spring returns the metering rods to a raised position with the engine off. Spraying some penetrating oil into the bowl vent and tapping on the metering rod hanger with a screwdriver or punch can often loosen the metering rods. See Photo 5.

Quadrajet Adjustments
  The Quadrajet has a number of critical adjustments that make it perform better. The initial adjustment for idle mixture screws on most Q-jets, for example, should be lightly seated and then photo 6: metering rod travel can be easily checked by inserting an applicable tool into the front float bowl vent. backed out three turns. Initial idle speed can be obtained by seating the primary throttle plates and then turning the idle speed screw in about two turns.

photo 7: the secondary metering rod height adjustment should be checked to ensure delivering a correct secondary air/fuel ratio.Primary jetting is most easily corrected by increasing the jet size in two-step increments. To remove the primary metering rods, lightly tap the metering rod hanger with a screwdriver handle. Spring pressure will pop the plastic retainer from the main body casting.

  Before installing any Q-jet, make sure that the secondary throttle plates are seated and that the secondary throttle linkage is adjusted to specification. A tab on the primary throttle shaft actuates the secondary linkage. This tab determines the open position of the secondary plates. When the tab contacts the secondary linkage, the linkage pushes against the upper part of the secondary throttle shaft lever. At that point, the linkage should be located mid-point in the slot located below. See Photo 6.

photo 8: use a 3/32” hex wrench to loosen the lock screw on the air valve spring preload adjustment. On the topside, the secondary metering rod hanger should be adjusted to ideally achieve equal metering rod height and to allow both metering rods to touch the bottoms of their respective wells. This adjustment is done incrementally to avoid binding the rods in their hanger and to avoid damaging the hanger itself. See Photo 7.

 Secondary air valve adjustment is critical to Quadrajet performance because correct secondary air/fuel metering requires a constant depression or vacuum in the secondary venturis. If a repair manual with adjustment specifications is available, begin with the applicable spec. If a specification is not available, preload the air valve spring adjustment one-half turn, Photo 9: Make sure the secondary throttle lockout disengages when the choke valve opens.  then road test the vehicle. If the engine stumbles as it accelerates, increase the spring preload in one-half turn increments until the stumble disappears. See Photo 8.

Last, always make sure that the choke valve lockout is allowing the secondary throttle plates to open. Some Quadrajet models incorporate the lockout at the upper choke housing linkage while others locate the lockout  at the secondary throttle shaft. In either case, the choke valve linkage keeps the air valves closed until the engine warms up. See Photo 9.

Quadrajet Wrap-Up
When serviced correctly, the Quadrajet will prove to be a very responsive and economical carburetor to use for many street driving and racing applications. Although Quadrajet is very dependable, it pays to clean the external choke linkage and air bleeds with an aerosol cleaner. When changing the fuel filter, remember to replace the plastic gasket located on the end of the fuel inlet housing before reinstalling. Cross threading the inlet housing can be greatly reduced by cleaning and oiling the housing threads before installation. If the threads are seriously damaged, aftermarket kits can be used to replace the factory housing. In virtually all cases, a well-maintained late-model Quadrajet will maintain exhaust emissions within legal limits for collector and street rod vehicles while providing a full-bore performance experience.

You May Also Like

Road to AAPEX Season Two: The Lincoln Highway

This year, the spotlight shines on a 2002 Lincoln Blackwood as it travels on a historic journey along the Lincoln Highway.

Another automotive adventure is about to unfold as Babcox Media presents "The Road to AAPEX Season Two, The Lincoln Highway." This year, the spotlight shines on the remarkable 2002 Lincoln Blackwood as it travels on a historic journey along the iconic Lincoln Highway - the first transcontinental highway in the United States, running coast-to-coast, designed exclusively for automobiles, and dedicated on Oct. 31, 1913. Coincidently, the AAPEX 2023 show kicks off on the Lincoln Highway's 110th anniversary.

Transmissions – CVT

Knowing what the common issues are & understanding the options available to isolate & fix problems are the keys to success.

Simplifying AWD Systems

No matter the manufacturer, there is almost always an all-wheel drive (AWD) option for most platforms.

Manual Transmission Service

Parts that wear out must be replaced.

Transmission Fluid Hydraulics

You need to know how transmission fluid flows inside an automatic transmission.

Other Posts

Coats Expands Maxx Tire Changer Line With MAXX 50

The base Maxx tire changer platform now comes in 4 models total.

AP Emissions Unveils August New Product Announcement

10 new 46-state Federal EPA part numbers have been released.

Hunter Engineering Expands Supply Capabilities in Missouri

Company continues to efficiently serve customers despite supply chain challenges.

Autel Adds EV Diagnostics, Maintenance to Class Roster

Classes are intended for current and potential owners of Autel EV diagnostic tablets.