Tech Tip: Diagnose and Repair ABS on Ford Trucks

Tech Tip: Diagnose and Repair ABS on Ford Trucks

As you are all very well aware, occasionally anti-lock brake system (ABS) malfunctions can be very complicated and hard to diagnose. In the case of some late-model Ford truck anti-lock brake systems, however, several malfunctions may have a very simple solution.

As you are all very well aware, occasionally anti-lock brake system (ABS) malfunctions can be very complicated and hard to diagnose. In the case of some late-model Ford truck anti-lock brake systems, however, several malfunctions may have a very simple solution.

Some 1997-1999 Ford Expedition, F-150, F-250 (2WD models only), or 1998-1999 Lincoln Navigator (2WD models only), can exhibit such diverse symptoms as: ABS lamp illumination, false ABS cycling at low speeds, increased brake pedal effort at low speeds, or any combination of the above. These problems all may be caused by an incorrectly installed front wheel speed sensor, a damaged wheel sensor, or a chipped or broken tooth on the tone ring resulting in reduced input to the ABS Electronic Control Unit (ECU). Refer to the following Service Procedure for details.

SERVICE PROCEDURE
1. If the ABS lamp is on, retrieve and record any diagnostic trouble codes.

NOTE: Usually codes C1145, C1148/1234, C1155, C1158/1233 or C1222, which are all related to a front wheel sensor malfunction, will be displayed.

2. Inspect both front sensor wires for tension due to improper routing (Figures 1 and 2). Make sure that the white clip, attached to sensor cable is properly located on protrusion of the upper control arm (Figure 1). Replace the sensor assembly if needed.


3. Carefully inspect the sensor wire at the sensor head. Look for any cracking or distress. Replace the sensor assembly if needed.

4. Inspect the tone ring for dents, flat spots, chips or other irregularities.

5. Inspect both front sensor bodies for improper seating to the spindle housing. The sensor bracket flange should be completely flush to the spindle housing (Figure 3). If any gap is present, replace the sensor assembly with a new front wheel speed sensor.



PARTS INFORMATION

• Front wheel Speed Sensor — (RH) XL3Z-2C204-BB.
• Front wheel Speed Sensor — (LH) XL3Z-2C205-AB.

If sensor replacement is required, all surfaces, including the hole where the sensor body is inserted, must be free of rust build-up. Use a wire brush to thoroughly clean all surfaces where the sensor seats. That’s all there is to it. Make certain that you clear any ABS codes that were displayed and test-drive the vehicle to confirm your repairs.

Written by ALLDATA Technical Editor, Rich Diegle. Rich is an Advanced Engine Performance Certified and ASE Master Technician with an Associate of Arts degree in automotive technology and 22 years of dealership and independent shop experience.

For additional information, visit www.alldata.com.

You May Also Like

R1234yf: Smaller Footprint, New Diagnostics

The benefit of R1234yf is simple. The new refrigerant lasts only 11 days in the atmosphere compared to 13 years for R134a. This is why the EPA is requiring R1234yf to be installed in all new systems by 2021.

r1234yf featured

The benefit of R1234yf is simple. The new refrigerant lasts only 11 days in the atmosphere compared to 13 years for R134a. This is why the EPA is requiring R1234yf to be installed in all new systems by 2021. The European Union required the changeover on Jan. 1, 2017.
So, what does this mean for independent shop owners and technicians? Currently, there are approximately 20 million vehicles on the road with R1234yf in the HVAC system. It is not a question of if, but when your shop will have to deal with one of these systems. While working on R1234yf systems is not that different from the R134a variety in operation or theory, identifying the refrigerant and recharging the system has some new twists.

Kia Tech Tip: Power Steering Oil Pump Noise

When replacing a power steering oil pump or inspecting a vehicle for a power steering whine noise, inspect the filter screen in the power steering reservoir for contamination.

Chevrolet Tech Tip: ABS Light On, DTC C1233

Don’t always jump to conclusions. A wheel-speed-sensor-related trouble code does not always mean that the sensor itself is faulty. SureTrack provides multiple possible solutions to one problem. In this situation, the problem is code C1233. Scan over this Real Fix and see if it is the right fix for you.

Anti lock brake system
2013 Ford: No Radio, No A/C, Airbag Light On

How many times have you been working on the computer when it suddenly locks up? Not one single key or command works, and the more you click, the less it responds. The only thing left to do is hold down those three magic keys, “Ctrl-Alt-Del,” or shut the whole thing off and restart the computer.

GM Tech Tip: Clunk Or Thump Noise From Front Suspension

Some customers may comment on a clunk or thump noise coming from the front suspension while driving over rough road surfaces. This noise will typically occur when the front suspension is returning to the upward position after a hard downward stroke, such as after driving through a large rut or pothole.

gm-suspension-noise-featured

Other Posts

Tech Tip: Ford/Lincoln/Mercury Transmission Fluid Leak

Follow these tips to diagnose and fix a transmission fluid leak on several Ford, Lincoln and Mercury models. The first step is to remove the LH halfshaft and inspect the halfshaft journal surface finish.

Transmission leak
Automotive Automatic Transmission Filter O-Rings And Lip Seals

Many transmission filters require a seal at the point where they assemble into the transmission. Most of these seals are called “lip seals,” although some filters may use an O-ring. Before filter installation, it is important to make sure that there is no O-ring or lip seal in the case or pump bore left over from the old filter.

BRAKELIGHT: The Car Cradle (March 1986)

Some ideas just never catch on… Related Articles – Welcome To The Future: Are Your Networks Protected? – BRAKELIGHT: BFE Sponsors Soapbox Derby – BRAKELIGHT: Spiffs from the 1970s (1976) I wonder if the Car Cradle paid for itself by shaking out the coins that were trapped in the seats? The ad claims that there

Welcome To The Future: Are Your Networks Protected?

For those of you who do not know me, I will give you a quick download on my background. Related Articles – BRAKELIGHT: Ford Helps Disabled Veterans (June 1951) – BRAKELIGHT: Wreck Display Increases Brake Business 150 Percent (August 1936) – Brakelights: Foam Means Fade (June 1961) I have been playing with cars for 40

cybersecurity